Organic matter removal and ammonia recovery by optimised treatments of swine wastewater

The organic matter and nitrogen contents of swine wastewater (SW) can be reduced and, at the same time, a fertiliser as ammonium salt can be recovered by wastewater treatments. One of the most promising technique is air stripping (AS). However, the operational parameters (pH, temperature and air flow rate) of AS must be optimised, in order to maximise the ammonia recovery and reduce the requirement of chemicals and energy.In this study 27 batch tests at laboratory scale were carried out on real SW, varying (individually or simultaneously) the pH (not adjusted, 8 and 10), temperature (ambient, 40 and 60 °C) and flow rate (0, 1 and 5 Lair LSW−1 min−1) of AS; the changes in soluble COD (sCOD) and total ammonia nitrogen (TAN) concentrations were evaluated in response to the parameters adjustments. For the tests including AS, the ammonium sulphate recovered was also measured.In general (about 50% of the tests), more than 80% of TAN was removed. Most of these tests were carried out with pH and temperature control and AS at the highest flow rate; the highest efficiency was found for a combination of chemical, thermal and aeration treatments. For a few tests with the same process control, an increase (up to 50%) or a very limited (less than 10%) decrease of sCOD were detected; therefore, these treatments can be adopted prior of anaerobic digestion of SW. A high flow rate, which increases the removal efficiency of both sCOD and TAN, should be adopted, when AS is used as pre-treatment of activated sludge or lagooning plants. Very high amounts (over 80% of the theoretical yield) of ammonium sulphate were recovered by AS at the maximum air flow rate (5 Lair LSW−1 min−1), which would provide a nitrogen fertiliser at a sustainable cost.